Abstract
It is very important to understand the annular multiphase flow behavior and the effect of hydrate phase transition during deep water drilling. The basic hydrodynamic models, including mass, momentum, and energy conservation equations, were established for annular flow with gas hydrate phase transition during gas kick. The behavior of annular multiphase flow with hydrate phase transition was investigated by analyzing the hydrate-forming region, the gas fraction in the fluid flowing in the annulus, pit gain, bottom hole pressure, and shut-in casing pressure. The simulation shows that it is possible to move the hydrate-forming region away from sea floor by increasing the circulation rate. The decrease in gas volume fraction in the annulus due to hydrate formation reduces pit gain, which can delay the detection of well kick and increase the risk of hydrate plugging in lines. Caution is needed when a well is monitored for gas kick at a relatively low gas production rate, because the possibility of hydrate presence is much greater than that at a relatively high production rate. The shut-in casing pressure cannot reflect the gas kick due to hydrate formation, which increases with time.
Article PDF
Similar content being viewed by others
References
Barker J W and Gomez R K. Formation of hydrates during deepwater drilling operations. Journal of Petroleum Technology. 1989. 41(3): 297–301
Dholabhai P D, Kalogerakis N and Bishnoi P R. Kinetics of methane hydrate formation in aqueous electrolyte solutions. Canadian Journal of Chemical Engineering. 1993. 71(2): 68–74
Ebeltoft H, Yousif M and Soergaard E. Hydrate control during deep water drilling: overview and new drilling fluids. SPE Annual Technical Conference and Exhibition, 5–8 October 1997, San Antonio, Texas (SPE 38567)
Fossil B and Sangesland S. Managed pressure drilling for subsea applications: well control challenges in deep waters. SPE/IADC Underbalanced Technology Conference and Exhibition, 11–12 October 2004, Houston, Texas (SPE/IADC 91633)
Handa Y P. Compositions enthalpies of dissociation, and heat capacities in the range 85 to 270 K for clathrate hydrates of CH4, C2H6, C3H8. Journal of Chemical Thermodynamics. 1986. 18(7): 915–921
Hasan A R and Kabir C S. Aspects of wellbore heat transfer during two-phase flow. SPE Production & Facilities. 1994. 9(4): 211–216 (SPE 22948)
Jamaluddin A M, Kalogerakis N and Bishnoi P R. Modeling of decomposition of a synthetic core of methane gas hydrate by coupling intrinsic kinetics with heat transfer rates. Phys. Chem. 1989. 67(6): 948–954
Kim H C, Bishnoi P R and Heidemann R A. Kinetics of methane hydrate decomposition. Chemical Engineering Science. 1987. 42(7): 1645–1653.
LeBlanc J L and Lewis R L. A mathematical model of a gas kick. Journal of Petroleum Technology. 1968. 20(8): 888–898
Loevois J S, Perkins R, Martin R J, et al. Development of an automated high pressure heat flux calorimeter and its application to measure the heat of dissociation and hydrate member of methane hydrate. Fluid Phase Equilibrium. 1990. 59: 73–79
Nickens H V. A dynamic computer model of a kicking well. SPE Drilling Engineering. 1987. 7: 158–173
Nunes J O L, Bannwart A C and Ribeiro P R. Mathematical model of a gas kick in deep water scenario. IADC/SPE Asia Pacific Drilling Technology, 8–11 September 2002, Jakarta, Indonesia (SPE/IADC 77253)
Rueff R M, Sloan E D and Yesavage V F. Heat capacity and heat of dissociation of methane hydrates. AIChE J. 1988. 34(9): 1468–1476
Santos O A. A mathematical model of a gas kick when drilling in deep waters. MS Thesis. Colorado School of Mines. 1982
Vysniauskas A and Bishnoi P R. A kinetic study of methane hydrate formation. Chemical Engineering Science. 1983. 38(7): 1061–1072
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Wang, Z., Sun, B. Annular multiphase flow behavior during deep water drilling and the effect of hydrate phase transition. Pet. Sci. 6, 57–63 (2009). https://doi.org/10.1007/s12182-009-0010-3
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12182-009-0010-3